Fuel filter Daewoo Nexia. Fuel filter for Daewoo Nexia Nexia 16 valve where are the gasoline filters located?
Fuel filter installed on the bottom of the car, on the starboard side, next to the fuel tank.
We carry out the work on an inspection ditch or overpass.
The fuel in the engine power system is under pressure. Therefore, before servicing the power system, it is necessary to relieve the fuel pressure. To do this, with the ignition off...
...take it out mounting block relay in instrument panel fuel pump
.
We start the engine and let it run for idling before stopping due to fuel exhaustion in the system. Then turn on the starter for 2-3 seconds. As a result, the pressure in the power system will be relieved. 
.
Similarly, disconnect the fitting of the other fuel pipe. 
.
.
.
If necessary, replace the O-rings with new ones.
The arrow on the fuel filter should be directed in the direction of fuel flow (towards the front of the car).
When installing the filter... 
...we bait the fittings fuel pipes by hand...
...and tighten them one by one. We tighten the bolt securing the clamp. Having installed new filter, check the tightness of the connections while the engine is running.
The function of cleaning the gasoline supplied to the engine is assigned to the fuel filter. The debris in the fuel gradually clogs the consumable. This causes increased load on the fuel pump and can also cause unstable work engine. Therefore, it is important to observe the frequency of replacing consumables and strictly follow the manufacturer’s recommendations for choosing a filter element.
Article number and approximate cost of a branded fuel filter and its analogues
On Daewoo Nexia There is a fine fuel filter. It is the same regardless of whether the car engine has 8 valves or 16 valves. The original consumable has one of the following catalog numbers:
- 96130396;
- 25055129;
The cost of a native fine filter ranges from 500 to 750 rubles. Analogs of the branded filter are also available for sale. The best alternatives are shown in the table below.
Table - Analogues of the fine fuel filter for the Daewoo Nexia car
| Manufacturer | Article number | Estimated cost, ruble |
|---|---|---|
| Profit | 15302903 | 165-200 |
| Bosch | 0986450119 | 365-410 |
| Parts-Mall | PCC002 | 210-270 |
| Mann-Filter | WK6122 | 550-630 |
| TRW | F185 | 1600-2700 |
In addition to the fine filter, the Daewoo Nexia has a mesh that catches large debris. On cars manufactured before 2002, the filter mesh used has article number 96183953.
A branded coarse filter costs from 160 to 220 rubles. It is also possible to buy analogues from other brands. The table shows the best nets for cars produced before 2002.
Table - Alternatives to native mesh 96183953
Daewoo Nexia cars manufactured after 2002 use a mesh filter with catalog number 96350078-2. The cost of a branded mesh ranges from 30 to 80 rubles. The best analogues of filter mesh can be found in the table below.
Table - Analogs of mesh filter 96350078-2
In some cases, instead of replacing the filter mesh, it is more profitable to install a new fuel pump assembly. For Daewoo Nexia cars produced before 2002, a unit with article number 96350078 is required.
The price for consumables varies from 1000 to 1800 rubles. The network also offers the opportunity to purchase an analogue. The best alternatives are presented in the table below.
Table - Analogues of the Daewoo Nexia branded fuel cup until 2002
| List of companies | Article number | Approximate price, ruble |
|---|---|---|
| Profit | 40010035 | 1350-1700 |
| ERA | 775242A | 1650-2200 |
| Onnuri | 96494976 | 1550-1950 |
| Parts-Mall | PDCM001 | 1750-2500 |
| Japan Cars | O20010JC | 950-1400 |
On Daewoo cars Nexia after 2002 production costs a fuel filter 96494976. Its cost varies from 2700 to 3000 rubles. The best analogues of the native node are given below.
Table - Analogs of the original fuel module for Daewoo Nexia after 2002
| Manufacturer | Filter article number | Approximate price, ruble |
|---|---|---|
| Onnuri | 96494976 | 2000-2500 |
| ERA | 775242A | 1650-2000 |
| Profit | 40010035 | 1400-1600 |
| Parts-Mall | PDCM001 | 1800-2300 |
| Asam | 50070 | 1050-1400 |
Fuel filter location
The fine fuel filter is located on the Daewoo Nexia under the bottom of the car. It is located with right side.
The coarse mesh is assembled with the fuel pump. The pump is placed directly into the gas tank.
Replacing the fine fuel filter
Replacing the fine filter is shown below.
- Relieve pressure in the fuel circuit.
- Clean the fuel filter from external dirt.
- Unscrew the pipes.
- Loosen the clamp.
- Remove the filter.
- Replace the O-rings.
- Install a new filter.
- Check for leaks.
Replacing the mesh filter
Replacing the coarse filter is carried out according to the instructions presented below.
- Remove the back row.
- Raise the casing.
- Open the hatch.
- Disconnect the terminal and relieve pressure in the line.
- Unscrew the clamp and disconnect the fuel line.
- Unscrew the fuel pump mount.
- Remove the pump.
- Replace the mesh.
- Install everything back.
The quality of the fuel at our gas stations speaks for itself about the need to replace the fuel filter and monitor its condition. Regulations Daewoo service Nexia advises doing this after a mileage of 40 thousand km. However, given the operating conditions and the comparative ease of work, it is better to reduce the mileage before replacement to 15-20 thousand.
Where is the fine fuel filter located in Daewoo Nexia
The full-flow fine filter is located at the rear of the vehicle to the right of fuel tank.
His task- protect the food system from harmful impurities and small suspended particles. Even considering that there is a coarse filter in the fuel tank, it is not able to fully protect injection system power from the smallest particles. When suspension gets into the injectors, their service life is significantly reduced and the operation of the injection system deteriorates. In addition, the fuel filter protects the fuel line and system elements from corrosion caused by the inevitable entry of moisture into the fuel.
Which one is better to choose?
To replace the old filter, both in eight- and 16-valve modifications, the plant recommends using branded korean filter Daewoo with article number 25055129 .
However, many use less expensive analogues Mann, Fram, Profit, Valeo, Stellox . Their price ranges from 300 to 800 rubles, depending on the brand, since buying an expensive filter, given the short replacement time, is not always cost-effective.
Required tool for replacement
It is more convenient to remove the fine filter using open-end wrenches 16 and 21, previously modified using a grinder.
To replace the filter you will need:
- Tricky keys for 16 and 21.
- Standard set of tools.
- Penetrating lubricant WD40.
- Container for draining gasoline from the old filter.
- New filter with seals (not included).
Detailed algorithm
First you need to relieve the pressure in the fuel line. To do this, you need to get to the power contacts of the fuel pump.
- The fuel pump is installed in the fuel tank, and access to its power contacts is through a hatch under the rear seat.
- Therefore, we remove the pillow, fold back the valve, remove the plastic hatch cover and carefully remove electrical connectors on the fuel pump.
- We start the engine, it should idle and stall after 15-20 seconds when all the fuel is used up.
Turn off the ignition and proceed to replacing the filter. It is more convenient to work on a lift or inspection pit.
- Remove the negative terminal on the battery.
- We hold the fuel filter with a 21 wrench, and with a 16 wrench we unscrew the inlet and outlet fittings. At this stage, difficulties may arise, since the location of the filter is such that all the moisture and dirt from under the wheels falls directly onto it. It is better to treat the fittings and the filter housing clamp mounting bolt with penetrating lubricant in advance.
To avoid breaking the nuts, soak the joints with penetrating lubricant.
- Place a container under the filter and drain the remaining gasoline.
- Using a 13 mm socket or a spanner, unscrew the bolt securing the clamp.
- We take a new filter and find an arrow on its body indicating the direction of fuel movement.
- We screw the new filter with the clamp with a bolt.
- We check the condition of the rubber gaskets in the fittings. If they are bad, we replace them.
We install a new filter and connect the fuel pipes, observing the direction of the arrow.
- We put the terminals on the fuel pump and on the battery and start the engine. We check the tightness of the fittings on the filter.
Conclusions
At the slightest sign of fuel leakage, turn off the engine and fix the problem. This way you can quickly change the fuel filter on a Daewoo Nexia with your own hands. Clean gasoline and good roads to everyone!
Video about what is inside the Korean Daewoo fuel filter
Replacing the Daewoo Nexia fuel filter, according to the manufacturer’s recommendation, it should be performed every two years of vehicle operation or after 40 thousand km. If low-quality fuel is used, the filter service life is only 10–15 thousand km.
You can easily determine the need to replace the filter yourself. If the car is high speeds starts to move jerkily - this is the first sign of a malfunction. With further operation, jerks occur even at low speeds, after which operation of the machine becomes impossible.
The location of the fuel filter on the Daewoo Nexia is not entirely convenient: it is located at the base of the body near the fuel tank, directly under the threshold of the rear right door.
Tools and materials for replacing the filter:
- pliers;
- Phillips and flat screwdrivers;
- rags;
- wrenches for 13, 21 and 16, both open-end and ring;
- new original fuel filter;
- spare clamps and clamps;
- jack.
Sequence of work for replacing the fuel filter
It is more convenient to carry out the work on an inspection hole, a lift or an overpass. As a last resort, you can use a jack and lift only the rear right side of the car. 
First of all, it is necessary to relieve the pressure in the fuel system. To do this, you need to find the fuse responsible for the operation of the fuel pump and turn it off, then start the car and let it run until it stalls. 
Next, you need to unscrew the supply pipes from the filter. To do this, use a 21 key to hold the fitting located on the filter, and use a 16 key to release the fittings of the suitable fuel pipes. 
Using a 13mm wrench, unscrew the clamp securing the filter. After this, you can completely disconnect the fuel pipes and the O-rings located under them. 
After which a new fuel filter is installed and everything is assembled in reverse order.
Replacing the Daewoo Nexia fuel filter- This simple procedure, but it has its own subtleties. When installing a new filter, the inscription IN, which can be seen on its end, must be positioned towards the fuel supply pipe. There are filters that do not have such markings; in this case, there should be an arrow on its end indicating the direction of fuel flow. 
When replacing the fuel filter, it is advisable to also change the o-rings located under the fuel pipe fittings, regardless of their condition.
Daewoo Nexia is one of the most important elements fuel system car. Its main function is to purify fuel. Naturally, over time it becomes dirty and requires replacement. The article contains detailed instructions carrying out this procedure, as well as recommendations on when to change the fuel filter.
[Hide]
When to change?
Daewoo Nexia has a full-flow fuel filter with fine cleaning, it is located in the rear of the car on the right side in front of the gas tank and is attached to the right longitudinal beam of the body. It has a steel body, inside of which there is a filter element made of paper folded in the form of an accordion.
Gasoline sold at gas stations is not always different good quality. It often contains various impurities. In addition, containers in which gasoline is stored and transported are susceptible to contamination. Accordingly, rust and contaminants can get into gasoline. If you refuel your car during rain and snow, condensation may subsequently form in the car’s gas tank. All these factors negatively affect the quality of gasoline.
To protect the fuel system from corrosive processes, foreign particles and premature wear intended filter element. Its main task is to clean the fuel from foreign particles and impurities.
Fuel filter
If the filter element becomes dirty, the car loses power, the engine starts poorly, runs unstably, and fuel consumption increases. Low-quality gasoline causes jerking high speed, and then at low levels, which indicates clogging. This may cause transmission damage or create emergency situation on the road. The situation can be corrected by replacement.
Manufacturers recommend replacement after 40 thousand mileage or after two years of operation. The service life of the filter element largely depends on the quality of the fuel. Based on the experience of using Daewoo Nexia in domestic conditions, it is recommended to replace it after 15 thousand mileage.
Replacement instructions
It is more convenient to perform the procedure on an inspection hole, overpass or lift. If this is not possible, then you should raise the right back car using a jack.
Tools
To carry out the procedure you need to prepare:
Chopiks are wooden sticks, pointed to a cone at the end. They are used to plug fuel lines.
Steps
- First, disconnect the ground wire from the battery terminal.
- The pressure in the fuel system should also be relieved.
- The fuel filter must be cleaned of contaminants.
- Next, use a key set to “16” to loosen the fittings from fuel lines, in this case the fitting on the filter can be held using a key at “21”.
- After the work has been done, start the engine and let it run idle for 5 minutes. After this, it is necessary to check the pipe connections for leaks. If there are any leaks, the fastening nuts should be tightened.
Timely replacement of the fuel filter on Daewoo Nexia will extend the life of the vehicle and contribute to stable engine operation.
Video “Replacing the fuel filter”
This video shows the process of replacing the fuel filter in the same way it is changed on the Daewoo Nexia.