Replacing the cabin filter of the Opel Astra G: the significance of the operation to ensure proper operation of the ventilation system, frequency and order of work.

The Opel Astra G cabin filter is involved in the operation of the air conditioning system. The operation to replace this element is regulated by the German company to be carried out at the first maintenance. The frequency with which the Opel Astra G cabin filter is replaced is set by the factory at 15 thousand km. However, during intensive use in the urban cycle or in difficult conditions, it is recommended to install a fresh filter after 10 thousand mileage. Many owners use seasonal replacement– after a dusty summer or a changeable climate in the winter season.

What you need to know

Timely replacement of the Opel Astra G cabin filter contributes to high-quality cleaning of the intake air. This circumstance is important for two reasons:

1. Security efficient work air conditioning system, which is directly related to the cleanliness of the surface of the air conditioner radiator.
2. Cleaning the air entering the cabin. If the cassette is highly contaminated, dust particles will not only penetrate inside, but the contaminated surface of the filter material will become a breeding ground for pathogenic bacteria.

Even if there is no air conditioner in the blowing system, a filter is provided in the design. Instead of the model, a carbon element is installed to protect against dust.

The answer to the question of how to change a cassette in an Opel Astra G must start from the installation site. Traditionally, in Opel, the compartment where the replacement element is located is located behind the glove box. Access to the place where the Astra G cabin filter is located will be indicated by a thematic video or a described algorithm for carrying out the work.

Procedure for replacing the cabin filter in the Opel Astra G

The upcoming replacement of the cabin filter in the Opel Astra G will require a Phillips screwdriver. At the initial stage, unscrew the fastening screws of the built-in glove box to get to the place where the Astra G cabin filter is located. There are 6 of them around the perimeter. Having closed the glove box lid, we remove the entire glove box. You should pay attention to the wiring that provides illumination of the glove box. Rough handling may cause wire breaks.

Access to the compartment for replacing the cabin filter in the Opel Astra G is open. Closer to the central tunnel there is a compartment cover with a replaceable cassette. It is mounted on two clamps, and in some versions using threaded connections.

After opening the compartment, the used element is removed. His condition must be assessed. During subsequent operation, the owner can adjust the frequency of replacement if the filter is heavily soiled.

Before installing a new filter element, remove any remaining dust from the plastic housing. The replacement element must be installed taking into account the marked arrows indicating the direction for installation. The assembly process is carried out in reverse order. Replacing the cabin filter in the Opel Astra G is complete.

Instructions in photo

Using TORX 20, unscrew the three screws securing the glove box
... and three bottom mounting screws
Pulling the box towards you, we take it out

Disconnect the wire block
Remove the cabin filter cover fastening

Sometimes Opel owners Astra H is faced with the fact that the stove begins to work poorly. In order to determine the reason for this, you do not need to go to a car service center. As a rule, problems in the functioning of climate control arise due to contamination of the cabin filter. To make sure of this, you need to evaluate the condition of the filter element. And if it is not satisfactory, then it should be replaced cabin filter Opel Astra H for new. According to official recommendations, the filter must be changed after every 30,000-40,000 kilometers.

It is quite possible for a car enthusiast to replace the cabin filter on his own. Moreover, it takes little time. In order to remove and replace the Opel Astar H cabin filter, you will need a set of sockets and a Phillips-type screwdriver.

The filter element is located on the left side behind the glove compartment; to gain access to it, you first need to remove the glove box. Its fastening consists of four corner screws, we unscrew them with a screwdriver. In addition, there is a light inside the glove compartment that does not allow you to pull out the box, and therefore it is necessary to move aside the latches on which the lamp is attached. This can be done with a screwdriver or your fingers. Next, disconnect the plug with the wire from the backlight lamp. After this, you can remove the glove compartment by pulling it towards you. In addition, for greater convenience and full access to the filter cover, it is necessary to remove the decorative panel, which is installed on the air ducts for the front passenger seat. It is located under the glove compartment and secured with two swivel clips.

After removing the glove box, using a 5.5 mm socket, three screws are unscrewed on the filter cover, and two upper and one lower snap-on fasteners are also removed. By removing the cover you can see the dirty end of the filter element. Carefully remove the filter, bending it slightly. Of course, it is inconvenient to remove, but if you put in a little more effort, everything will go smoothly. Just then you need to remember to wipe off the dust that got from the filter into the housing.

Installing a new filter

Putting the filter back is even more inconvenient. The main danger is that the filter can be broken, but if it is in a plastic frame, this is unlikely. To install, place your right hand behind the filter and use your fingers to push it towards the cabin, at the same time pushing it inside. Having reached the middle, you need to bend it slightly and push it all the way. The main thing after this is not to discover that the side on which the element should be located towards the air flow is mixed up, otherwise you will have to repeat the installation procedure. After that, put it back and screw the lid on. It is better to make sure that it is hermetically sealed and pressed tightly to prevent dust from entering the interior.

An alternative option for installing a filter element:

• A strip of cardboard is cut out according to the shape of the filter and is slightly longer in size;
• Cardboard is inserted in place of the filter;
• The filter can be easily inserted along it without any effort;
• The cardboard is carefully removed.

The entire process of replacing the Opel Astra H cabin filter, if you have the right tool, takes about 10 minutes.
As an option, you can use a carbon filter, its quality is slightly higher than that of the “native” paper element. In addition, it is made in a rigid plastic frame, which makes it possible to install the filter almost effortlessly.

Car manufacturers install cabin filters in almost all new models. The importance of such a detail has been proven more than once by the following function: purifying the air that enters the cabin through the ventilation system. Capable of retaining dust, pollen during flowering, soot and other harmful components.

How does the cabin filter work?

The cabin filter, depending on its type, consists of several layers:

• 1 layer. Cleans the air from large particles of “garbage”.
• 2nd layer. Consists of synthetic fiber that attracts dirt particles. Significantly improves the air in the car interior.
• 3 layer. Material impregnated with activated carbon. Helps prevent harmful impurities contained in the exhaust gases of other cars from entering the cabin.

In the Opel Astra H, the cabin filter is located behind the glove compartment. The Opel Astra H cabin filter is replaced every 15-20 thousand kilometers.

The main signs of the need for replacement:

• If the air outside is clean and there is additional air in the car bad smell;
• When the ventilation system is turned on maximum speed, the power is not enough for high-quality airflow;
• The windows in the cabin sweat if there is high humidity outside.

If at least one of the above-described signs is present in the cabin, you will need to replace the cabin filter on the Opel Astra n. The procedure is carried out with your own hands with a minimal set of tools.

The process of replacing the cabin filter

To replace the filter element you will need the following tools and materials:

• Slotted and Phillips screwdriver;
• Set of heads;
• Cabin filter with article number 1987432040;
• Clean rags;
• Vacuum cleaner or compressor.

In the Opel Astra H, replacing the cabin filter is carried out according to the instructions presented below.

Step-by-step replacement instructions:

After replacement, you can check the stove. It should work like new. Clean air must enter the cabin.

Possible breakdowns and their causes

In the Opel Astra, the cabin filter must be replaced on time, and especially in cars with an air conditioning system, otherwise its components begin to wear out quickly. The reason is that when cold air enters the car, the evaporator begins to wear out. As a result, it fails. Expensive repairs and replacement of a new evaporator will be required. To prevent such a breakdown, the consumables must be changed in a timely manner - after the mileage has expired or according to the characteristic symptoms described above.

Also, when replacing, it is advisable to use a vacuum cleaner or compressor to blow out the installation area. This manipulation will protect against the rapid loss of effectiveness of the new filter.

On the Opel Astra j, the cabin filter must also be replaced in a timely manner to avoid problems with the vehicle.

Opel Astra H pretty reliable car and is quite easy to repair. Nose air filter we overdid it a little - it is in a hole from which it is difficult to get it out, and even if you managed to get it out, then do not rush to rejoice, because putting it back in is an even more difficult task. But we are not looking for easy ways, so we will remove this consumable, especially since we do not need dust in the cabin.

Original part number: 1 987 432 040
Analogs
Bosch 0 986 BF0 511
Champion CCF0013

Step-by-step instructions - removing and replacing the cabin filter on an Opel Astra H.

The cabin filter on the Astra H is located in the cabin behind the glove compartment, so first of all we need to remove the glove compartment. It is secured with four screws in the corners.

Unscrew them with a regular screwdriver.

There is a light inside the glove compartment, which will interfere with pulling out the box itself, you need to pull out the lampshade - it is attached to latches, just move them to the side, you can use your fingers, or you can pry it off with a screwdriver.

Now we disconnect the wire from the backlight bulb - there is a regular Opel plug.

Now you can take out the glove compartment - pull it towards you, nothing is holding it anymore.

The cabin filter is hidden under a plastic cover on the side. Screwed on with three 10mm wrench bolts.

Unscrew the bolts and remove the cover.

We pull out the filter - here the Germans are clever, you have to bend the filter in order to push it along the existing trajectory, but it doesn’t matter if you pull it a little harder, the main thing is not to forget to wipe the dust inside the filter housing.

This is how much dirt the filter has collected - there is no less dirt and dust inside the housing, so if you fight for air purity, then to the fullest.

Now I need to shove it new filter, and here pulling out the old one may seem like child's play! First you need to insert the filter halfway, then twist it approximately in the center so that it can fit further. But then at a certain stage he stops climbing - he just got stuck, you need to climb behind him with your hand and direct him a little, push him towards the cabin. When the filter goes to mounting hole, we must continue to cram in the unshoveable. Eventually he will climb.

Now put the lid on and screw it on. Make sure it is pressed tightly and airtight against the body. In this photo you can better see the filter housing along with the bolts.

In general, replacing the cabin filter on an Astra H is still a hemorrhoid, but if you have nothing else to do, then it’s a completely feasible task.

Good day everyone! In this manual you will learn how to perform replacing the cabin filter in Opel Astra N(Opel Astra H) with your own hands.

The need for replacement comes down to the fact that over time, the filter element of the heating and air conditioning system in the cabin loses its effectiveness. The efficiency of the heater or climate control system deteriorates, an unpleasant odor appears from the air ducts, and the car windows fog up in rainy or damp weather. If the first two signs affect only comfort, then the last one is very important for the safety of the driver and passengers. After all, foggy windows impair visibility, which can lead to an accident. That's why replacing the cabin filter Opel Astra N is very important procedure, which must be taken seriously.

Replace the cabin filter on an Opel Astra N in a car service it will cost the owner approximately 300-500 rubles. The work itself takes about 10-15 minutes and does not require any special skills or special tools. Therefore, this procedure can be completely carried out independently and even without a garage.

The Opel Astra N cabin filter itself can be purchased from our online store. To select a filter, it is best to use original catalogs. Or you can contact us and we will quickly select a filter for your car.

Instructions for replacing the cabin filter Opel Astra H

For replacing the cabin filter Opel Astra N we will need to remove the glove compartment.

1. Empty the glove compartment (glove box) of everything unnecessary.

2. Unscrew the 4 screws that secure the glove compartment. This is done using a regular Phillips screwdriver.

3. Now you need to remove the glove compartment light. Just pry it off with a flat screwdriver and pull it towards you. When the lamp is in your hands, remove the connector and move the lamp to the side.

4. Take out the glove compartment module and put it aside. Now we have access to the cabin filter. Or rather, not to the filter itself, but to the plug for the cabin filter.

5. Now you need to unscrew the 3 screws securing the cabin filter plug. To do this we need an 8" socket or a similar size wrench.

6. Remove the cover to the side and simply pull out the old filter element onto the passenger door. Be careful as a lot of debris accumulates on the filter.

7. Install the new cabin filter in place and assemble everything in reverse order.

All! It took us about 15 minutes of free time. By losing just fifteen minutes of free time, you will save about 500 rubles. But, as they say, if you save, you earn it.

Replacing the cabin filter Opel Astra N, You will immediately feel the difference, as the furnace and air conditioner will work like new. And window fogging will stop bothering you. Agree, not bad “bonuses”?

P.S.: I forgot to add that The cabin filter on the Opel Astra N is changing at least once every 30,000 - 35,000 km.